Analytical Methods for Lawful Sweetener Labeling

2018 SSC/David Plank - Analytical Methods for Lawful Sweetener Labeling
Click to Enlarge

THE REVISED U.S. NUTRITION LABEL regulations, to be implemented in 2020, will transform the carbohydrate portion of the label by including a line for added sugars along with revised definitions of dietary fiber. The food and beverage analysis industries are far from ready to accommodate these changes, explained David Plank, Ph.D., Managing Principal, WRSS Food & Nutrition Insights and Senior Research Fellow at the University of Minnesota, in his presentation, “Analytical Methods for Walking on the Lawful Side of Sugars, Dietary Fiber and Bioactive Sweeteners.”

“The FDA stated goals behind the regulatory changes are both to increase nutrition label transparency for consumers and to improve the health of the U.S. population via weight maintenance and a reduction in cardiovascular disease risks through reduced sugar consumption,” said Plank. The FDA’s goal for dietary fibers is transparency in order to erase the concept of “fake fiber” from nutrition labels. The objective now is to increase the consumption of “whole-grain, whole-food” fibers.

In regard to American food and beverage companies, the incentives are not just to avoid the wrath of the FDA for regulatory non-compliance, but also to avoid class-action lawsuits that will be brought whenever plaintiffs believe that they can demonstrate that food and beverage manufacturers have misled the “average” consumer. “Lawyers and consumers are always looking for a pay- day because they know that, in most cases, class-action lawsuits never go to trial but are settled out of court,” said Plank.

One of the potential warning signs should be if a formulation or label claim goes counter to the intent of the regulation, said Plank. He cited, as an example, a company adding a resistant starch to increase a product’s dietary fiber nutrition label declaration while also adding an amylase enzyme to digest the dietary fiber into glucose in order to increase sweetness. “Technically, it may be compliant with the letter of the regulations, but you will have violated the intent,” said Plank.

Plank identified two essential elements of the pending nutritional labeling regulations. The first element is that the label requires that all added mono- and disaccharides must be listed as “Added Sugars,” whether digestible or not. Thus, allulose and tagatose, which each contribute zero calories per gram, must be designated as “added sugars.”

Allulose, a monosaccharide, registers 0-0.4 Kcal/g and also inhibits” intestinal alpha-glucosidase, the enzyme that digests starch in the small intestine. Thus, not only is it non-caloric, it actually contributes the physiological benefits of a fiber through its action on reduced- starch digestion and concomitant reduced glycemic response,” said Plank. Even so, by the new regulations and existing current regulations, this physiological beneficial non-digestible carbohydrate must be labeled as added sugar, because it is a monosaccharide with less than a degree of polymerization (DP) of 3.

The second element is that none of the existing AOAC-approved dietary fiber analytical methods determine dietary fiber under the new regulations: They only measure non-digestible carbohydrates (NDC). However, when the existing AOAC-approved methods are used for determining insoluble and soluble NDCs in accordance with the new regulations, then a food manufacturer may claim zero calories per gram for the content of insoluble NDCs and 2 calories per gram for soluble NDCs on their food label—even if the NDCs do not physiologically qualify as dietary fiber. So, the determination of NDC content by these traditional AOAC analytical methods still has a practical benefit for those food manufacturers looking to make a low-caloric content product.

There are no analytical methodologies that can determine dietary fiber or added sugar as defined by the new regulations. As a result, food manufacturers are required to keep records of their food product formulations to support their nutrition label claims. FDA allows significant flexibility in how these records are constructed but does require them to be available for audit and maintained for a minimum of two years, post production.

The food analysis industry is hustling to catch up to the pending realities and liabilities of nutritional labeling compliance in 2020. They still have a long way to go.

“Analytical Methods for Walking on the Lawful Side of Sugars, Dietary Fiber and Bioactive Sweeteners,” David Plank, Ph.D., Managing Principal, WRSS Food & Nutrition Insights and Senior Fellow Researcher, University of Minnesota

This presentation was given at the 2018 Sweetener Systems Conference. To download free presentations and the Post-conference summary of this event, go to https://www.globalfoodforums.com/store/sweetener-systems-conferences/

See past and future Sweetener Systems Conferences at https://www.globalfoodforums.com/sweetenersystems/

Posted on:April 3, 2019

Leave a Reply

Your email address will not be published. Required fields are marked *


Recent Posts

Recent Comments

Archives

Recent Tags


Copyright© Global Food Forums®, Inc 2018 / all rights reserved